2019 Volvo S60 T6

2019 Volvo S60 T6 4 DR AWD

Overall

Not Rated

Front Crash

Not Rated

Side Crash

Not Rated

Rollover

Not Rated

FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING

Volvo Cars USA LLC (Volvo Cars) is recalling certain 2019-2020 S60, V60, V60 Cross Country, S90L, V90, V90 Cross Country, XC40, XC60, and XC90 vehicles. Due to a software/hardware incompatibility, the Automatic Emergency Brake (AEB) system may not detect obstacles and engage as intended.

Campaign: 20V144000

ELECTRICAL SYSTEM:WIRING:FUSES AND CIRCUIT BREAKERS

Volvo Car USA, LLC (Volvo Car) is recalling certain 2019-2020 V90, XC60, S60, V60, V60CC, S90, V90CC, S90L, and XC90 vehicles. The low-pressure fuel pump can blow a fuse and fail.

Campaign: 21V414000

SUSPENSION:REAR

Volvo Car USA LLC (Volvo) is recalling certain 2019 S60 vehicles. The rear suspension toe link flange lock nuts may not have been properly tightened, possibly resulting in a sudden change in vehicle handling.

Campaign: 19V327000

AIR BAGS:FRONTAL

Volvo Car USA, LLC. (Volvo Car) is recalling certain 2019-2024 S60 vehicles. The passenger air bag may not be secured properly, which can cause the air bag to deploy improperly.

Campaign: 23V780000

ELECTRICAL SYSTEM

The DIM (Driver Instrument Module) flickers intermittently and I have no idea when it's going to go out completely. It actually does go out and there's a solid white panel or colored lines, but it comes back in. This displays the speedometer & fuel. This is a safety issue. I would hate for this to go completely out while I am driving. I do not know the cause for the malfunction. However, per the Volvo tech; they're aware this is a reoccurring issue.

SEATS

Passenger seat was unbolted from floor during a service appointment and not secured when dealer returned vehicle to me. Passenger safety was at risk due to the seat rocking during acceleration and deceleration and in turns. The issue was confirmed by the dealer and has since been repaired. No warnings issued by vehicle. The dealer error occurred 10/16/24. It was corrected 10/17/24 after vehicle was returned to dealer. This was a result of dealer negligence.

EXTERIOR LIGHTING

2019 Volvo S60 headlamp system malfunction alert headlights/foglights to blink or turn off when turning the vehicle at night. I keep my headlights on auto so they are on during the day and I have only seen the error at night

TIRES

Have there been complaints about the Pirelli tires with foam inlays falling apart because the foam comes unattached, then causing misalignment. Car becomes unsafe to drive as the tires start to disintegrate. My car started shaking so bad it became difficult to drive. Turned out foam inlay had become unattached which caused uneven wear and some tire disintegration along with the alignment getting out of whack. Tire size 235/40R19 96V pirelli p-zero - It happened with all four tires. Two in the front were relatively new and had less than 10000 miles on them

SEAT BELTS

The passenger seat belt failed and will not retract. People riding in my car are not safe with the seatbelt hanging loose. I read this was a recall which included 2019 S60s but my specific VIN is not including for some reason.

STEERING,SUSPENSION,POWER TRAIN

Since purchase of my vehicle, the vehicle has had a vibration on the highway from 72-83mph with 2 different sets of wheels AND tires, both Pirelli tires but different models. My local Volvo dealer refused to address the issue due to the issue occurring over the speed limit. So they were no help. There are quite a few other 2019 and up Volvo S60 and XC90 owners that experience this same issue. The issue is felt through the bottom of the seats, backrest and steering wheel. You can also visually see the vibration if there is a bottle in the cup holder. The steering wheel "shakes" left to right.

TIRES

Sudden, Extreme vibration of front tires on I-95 West Palm Beach FL. Drove immediately to Schumacher Volvo to keep initial service appointment. Service manager advised to replace all 4 tires due to previous experience with OEM Perelli tire failures on Volvo vehicles. Replaced all 4 tires at Costco at $1112+ cost. All photos show failure of foam/padding inside tires by Pirelli P Zero Run Flat. Tire size: 235/40/19 XL

TIRES

235/40/19 XL RUN FLAT: At 20,750 miles, Sudden Extreme Vibration at Interstate Speed. Confirmed by Schumacher Volvo Service on 28 Oct 2023. Service Writer and Technician advised tire/s failing due to 'foam' separating inside tire. Rotated tires and could not determine which tire. Advised to replace all tires due to experience with same problem on same tires. Recommended purchasing another brand at Costco.

SERVICE BRAKES

Brake rotors warp prematurely, dealership fighting on covering for warranty. Only 10,000 miles and they're bad again. Second time in 10 months.

AIR BAGS

After taking vehicle in for a service SRS airbag light and getting it fixed under warranty the same light has come back on.